The engine exhaust from this product contains chemicals known to the State of California to cause cancer, birth defects, or other reproductive harm.

Transcrição

1

2 The engine exhaust from this product contains chemicals known to the State of California to cause cancer, birth defects, or other reproductive harm.

3

4

5

6

7

8 ±

9

10

11

12

13

14

15

16

17

18

19

20

21 Daily Maintenance Check For Week Of Maintenance Check Item MON TUES WED THURS FRI SAT SUN Safety Interlock Operation Grass Deflector in Down Position Brake Operation Fuel Level Engine Oil Level Cooling System Fluid Level Dust Cup and Baffle (Air Filter) Radiator & Screen for Debris Unusual Engine Noises Unusual Operating Noises Transmission Oil Level Hydraulic Hoses for Damage Fluid Leaks Tire Pressure Instrument Operation Condition of Blades Lubricate All Grease Fittings Touch up Damaged Paint

22

23

24 MAIN HARNESS F 1 15 A F A F 3 15 A OR GY PK BU X OFF B RUN I START A S Y Y VIO OPTIONAL LIGHT / FUSE BLOCK F A PK PK GN TO HIGH TEMP OVERRIDE SWITCH PK a OR OVER TEMP SHUT DOWN (CONNECTED TO GROUND ON OVER TEMP CONDITION) OR PTO SWITCH (OFF) GN R N.C. R FUSIBLE LINK HARNESS FL1 GY FL2 BK FL3 GY OR SEAT SWITCH (OFF) Y POSITIVE BATTERY CABLE B+ TIE POINT ON STARTER R (+) ( ) NEGATIVE BATTERY CABLE B B TO OVER TEMP SHUTDOWN RELAY ENGINE FRAME BATTERY GROUND GROUND GN PK D ALL MAIN HARNESS GROUND POINTS MARKED AS BLACK WIRE ARE CONNECTED TOGETHER AND TO THE ENGINE GROUND PK +8 7 BN PK (+) PK PK L PK PK L B R R PK GN BN HIGHTEMP OVERRIDE (MOMENTARY) (OFF) 4 3 HR ( ) BK S Y TEMP BU G BK S FUEL G BK PK C L W ALTERNATOR BN ENGINE OVER TEMP. (TEMPERATURE OK) Y TEMPERATURE SENDER BU FUEL SENDER BK ENGINE ENGINE BK KEY TO WIRE COLORS BK = BLACK GN = GREEN BR = BROWN GY = GRAY BU = BLUE T = TAN R = RED Y = YELLOW W = WHITE OR = ORANGE PK = PINK VIO = VIOLET LGN = LIGHT GREEN LBU = LIGHT BLUE B+ TO FUSIBLE LINK HARNESS VIO 30 87a 87 BU GY+BK BU B+ Start GN Y Y NEUTRAL SWITCH (NEUTRAL) START ENABLE BK STARTER Y W PARKING BRAKE SWITCH (ON) LOGIC DIODE (D2) W OR a RUN ENABLE BK BU BK PROTECTION DIODE (D1) R/BK R/BK ENGINE FUEL SOLENOID R/BK PK CONTROL 4 IGNITION DELAY MODULE OFF DELAY 0.5 SECOND 1 BK 3 2 PK R/BK R/BK BK OVER TEMP ALT OIL PRES A BN E F B GLOW CLUSTER GAUGE W GY FORD ENGINE HARNESS POWER GROUND VRS+ VRS 11 SPARK RETARD 7 A 10 BK R/LGN SPARK RETARD 8 B Y/LGN W/LBU CRANK POSITION SENSOR LGNW Y/LGN MAP A16 BR/W FUSE 7.5 A MAP SENSOR R/LGN BK MAP B17 G/BK GY W OIL PRESSURE SWITCH (LOW PRESSURE) SENSOR COM 9 COOLANT TEMP GN/R 18 LGN/R TEMP SENSOR ENGINE SPARK 1&4 6 Y/BK SPARK COM 4 R/LGN IGNITION COIL SPARK 2&3 3 Y/W IGNITION CONTROL MODULE I I

25

26

27

28

29

30

31

32

33

34

35

36

37

38

39

40 The Toro General Commercial Products Warranty A Two-Year Limited Warranty Conditions and Products Covered The Toro Company and its affiliate, Toro Warranty Company, pursuant to an agreement between them, jointly warrant your 1996 or newer Toro Commercial Product ( Product ) purchased after January 1, 1997, to be free from defects in materials or workmanship for two years or 1500 operational hours*, whichever occurs first. Where a warrantable condition exists, we will repair the Product at no cost to you including diagnosis, labor, parts, and transportation. This warranty begins on the date the Product is delivered to the original retail purchaser. * Product equipped with hour meter Instructions for Obtaining Warranty Service You are responsible for notifying the Commercial Products Distributor or Authorized Commercial Products Dealer from whom you purchased the Product as soon as you believe a warrantable condition exists. If you need help locating a Commercial Products Distributor or Authorized Dealer, or if you have questions regarding your warranty rights or responsibilities, you may contact us at: Toro Commercial Products Service Department Toro Warranty Company 8111 Lyndale Avenue South Bloomington, MN or commercial.service@toro.com Failures caused by outside influence. Items considered to be outside influence include, but are not limited to, weather, storage practices, contamination, use of unapproved coolants, lubricants, additives, or chemicals, etc. Normal wear and tear items. Normal wear and tear includes, but is not limited to, damage to seats due to wear or abrasion, worn painted surfaces, scratched decals or windows, etc. Parts Parts scheduled for replacement as required maintenance are warranted for the period of time up to the scheduled replacement time for that part. Parts replaced under this warranty become the property of Toro. Toro will make the final decision whether to repair any existing part or assembly or replace it. Toro may use factory remanufactured parts rather than new parts for some warranty repairs. General Conditions Repair by an Authorized Toro Distributor or Dealer is your sole remedy under this warranty. Neither The Toro Company nor Toro Warranty Company is liable for indirect, incidental or consequential damages in connection with the use of the Toro Products covered by this warranty, including any cost or expense of providing substitute equipment or service during reasonable periods of malfunction or non-use pending completion of repairs under this warranty. Except for the Emissions warranty referenced below, if applicable, there is no other express warranty. All Owner Responsibilities implied warranties of merchantability and fitness for use are As the Product owner, you are responsible for required maintenance and adjustments stated in your operator s manual. Failure Some states do not allow exclusions of incidental or consequential limited to the duration of this express warranty. to perform required maintenance and adjustments can be grounds damages, or limitations on how long an implied warranty lasts, so for disallowing a warranty claim. the above exclusions and limitations may not apply to you. Items and Conditions Not Covered This warranty gives you specific legal rights, and you may also have other rights which vary from state to state. Not all product failures or malfunctions that occur during the warranty period are defects in materials or workmanship. This express warranty does not cover the following: Note regarding engine warranty: The Emissions Control System Product failures which result from the use of non-toro on your Product may be covered by a separate warranty meeting replacement parts, or from installation and use of add-on, requirements established by the U.S. Environmental Protection modified, or unapproved accessories Agency (EPA) and/or the California Air Resources Board (CARB). The hour limitations set forth above do not apply to the Emissions Product failures which result from failure to perform required Control System Warranty. Refer to the Engine Emission Control maintenance and/or adjustments Warranty Statement printed in your operator s manual or contained in the engine manufacturer s documentation for details. Product failures which result from operating the Product in an abusive, negligent or reckless manner Parts subject to consumption through use unless found to be defective. Examples of parts which are consumed, or used up, during normal Product operation include, but are not limited to, blades, reels, bedknives, tines, spark plugs, castor wheels, tires, filters, belts, etc. Countries Other than the United States or Canada Customers who have purchased Toro products exported from the United States or Canada should contact their Toro Distributor (Dealer) to obtain guarantee policies for your country, province, or state. If for any reason you are dissatisfied with your Distributor s service or have difficulty obtaining guarantee information, contact the Toro importer. If all other remedies fail, you may contact us at Toro Warranty Company. Part No Rev.